Flight in ‘serious incident’ after every ‘Miss’ on board assigned child’s weight

Service to Majorca took off with less thrust because pilot thought it was 1,200kg lighter

Tui says the software error that affected flights has been corrected. Photograph: Matthew Horwood/Getty

Tui says the software error that affected flights has been corrected. Photograph: Matthew Horwood/Getty

 

An IT glitch caused a Tui flight to take off heavier than expected as women passengers using the title “Miss” were classified as children, an investigation has found.

The departure from Birmingham Airport to the Spanish island of Majorca with 187 passengers on board was described as a “serious incident” by the UK Air Accidents Investigation Branch.

An update to the airline’s reservation system while its planes were grounded because of the coronavirus pandemic led to 38 passengers on the flight being allocated a child’s “standard weight” of 35kg as opposed to the correct figure of 69kg.

This caused the load sheet – produced for the captain to calculate what inputs are needed for take-off – to state that the Boeing 737 was more than 1,200kg lighter than it actually was.

Investigators described the glitch as “a simple flaw” in an IT system. It was programmed in an unnamed foreign country where the title “Miss” is used for a child and “Ms” for an adult female.

Despite the issue, the thrust used for the departure from Birmingham on July 21st last year was only “marginally less” than it should have been, and the “safe operation of the aircraft was not compromised”, the AAIB said.

The same fault caused two other Tui flights to take off from the UK with inaccurate load sheets later that day.

The system was adapted when the problem was first identified 11 days earlier, but this did not correct the weight entries for the July 21st flights.

The operator subsequently introduced manual checks to ensure adult females were referred to as Ms on relevant documentation.

Tui said in a statement: “The health and safety of our customers and crew is always our primary concern. Following this isolated incident, we corrected a fault identified in our IT system. As stated in the report, the safe operation of the flight was not compromised.” – PA

The Irish Times Logo
Commenting on The Irish Times has changed. To comment you must now be an Irish Times subscriber.
SUBSCRIBE
GO BACK
Error Image
The account details entered are not currently associated with an Irish Times subscription. Please subscribe to sign in to comment.
Comment Sign In

Forgot password?
The Irish Times Logo
Thank you
You should receive instructions for resetting your password. When you have reset your password, you can Sign In.
The Irish Times Logo
Please choose a screen name. This name will appear beside any comments you post. Your screen name should follow the standards set out in our community standards.
Screen Name Selection

Hello

Please choose a screen name. This name will appear beside any comments you post. Your screen name should follow the standards set out in our community standards.

The Irish Times Logo
Commenting on The Irish Times has changed. To comment you must now be an Irish Times subscriber.
SUBSCRIBE
Forgot Password
Please enter your email address so we can send you a link to reset your password.

Sign In

Your Comments
We reserve the right to remove any content at any time from this Community, including without limitation if it violates the Community Standards. We ask that you report content that you in good faith believe violates the above rules by clicking the Flag link next to the offending comment or by filling out this form. New comments are only accepted for 3 days from the date of publication.